Welcome to your Pro 500!
Double spouted commercial portafilter, Single spouted commercial portafilter, Single basket, Double basket, Blind basket, Cleaning brush, Plastic tamper
Filling the Reservoir
- The Pro 500 operates on a 3 liter water reservoir located under the cup warming tray.
- Use soft potable water only and do not operate the machine without water.
- Your 3 Liter reservoir will make approximately 25-30 drinks before needing to be refilled.
- To fill reservoir:
- Remove the top warming tray and fill reservoir while seated in machine
- Alternately you can remove the reservoir from the machine to fill.
- Fill reservoir to about an inch below the top of the tank.
- Reseat tank in the same orientation that it was removed (see photo).
- The magnet float engages a sensor inside the machine, the float must be seated as show for the machine to function properly.
- The Pro 500 is a reservoir only model.
Power on Machine
- Your machine is set for use on a 110v outlet.
- Prior to starting the machine, check if the steam and hot water valves are closed. Check to ensure the machine is switched off (Power switch in lower position), and the drip tray is inserted accurately.
- Plug the machine directly into a grounded socket, do not use an extension cord or multiple socket.
- The On/Off Switch is located just below the green power lamp. Up position is on and you will see the green led illuminate; down position is off, you will see the green led light and machine power off.
First Time Startup
- Place the machine on an even and stable surface. You can regulate the height by adjusting the feet of the machine. Never place the machine on hot surfaces.
- Following the steps above, fill your water reservoir, plug in the machine, and turn it on.
- The pump will begin filling the boiler of the machine with fresh water. As soon as the boiler is filled, there will be no more pump noise; the orange control lamp is now on, this indicates that your reservoir has enough water. As soon as the fresh water sinks down to a certain level in the water tank, the machine will stop heating and the light of the orange control lamp will switch off. Refill with fresh water at this point.
- If the pump is running while the tank empties it will continue to function and you may hear the pump run dry. Cycling the brew lever off and on again, the pump will not reengage until the reservoir is refilled.
- A large amount of water is required for the first filling of the boiler, you can expect to refresh the water tank with water during this start up process.
- Wait until the boiler pressure gauge indicates approx. 1.0-1.25 bar.
- A manual “boiler ventilation” is not necessary because the PROFITEC PRO 500 is equipped with a professional depression valve that ventilates the boiler during the heat-phase.
- Dispense approximately 8oz of water from the grouphead. This way, the heat exchanger will be filled with water and the circulation of the water in the thermosyphon system begins.
- The machine is now ready for use. Put the cups on the cup heater tray in order to preheat them and get started making coffee!
Specifications and Technical information
|Drip Tray||Stainless steel|
|Drip Tray Cover||Stainless steel|
|Drip Tray capacity||32oz|
|Drainable Drip Tray||No|
|Reservoir or plumbed||Reservoir|
|Capacity||3 Liters/100 fl oz, makes approximately 25 beverages|
|Material||BPA Free Plastic|
|Low Water Shutoff||Yes|
|No Burn (insulated)||Yes|
|Wand Movement||Articulating, full rotation|
|Steam Tip Holes||4|
|Optional Steam Tips||Yes|
|Display Type||Indicator lights|
|Pressure Gauges||2, pump pressure and steam boiler pressure|
|Low Water Warning||Yes|
|CUP WARMING TRAY|
|Material||Chrome Plated Brass|
|Baskets Included||Single and double|
|Bottomless Portafilter||Available separately|
|Type||e61, lever activated|
|Maintenance||Urnex Full Circle or Cafiza backflush detergent|
|Boiler Automatically Fill||Yes|
|Heating Element Access||Accessible from side (boiler is horizontal)|
|Insulated||Yes, velcro wrap|
|Recommended brew pressure||9 bar|
|Adjustable brew pressure||Yes|
|Recommended Application||Home or office|
|NSF Certified for Commercial Use||No|
Still have questions? Email email@example.com